Used Iveco Stralis: 10 common problems

George Barrow
June 19, 2020

Click here to view all of the used Iveco Stralis trucks we have in stock.

While historically IVECO has been plagued with complaints about build quality, things have improved a great deal over the past few years, so the number of things to look out for has fallen accordingly. It is worth noting that all our operators, without prompting, said that their rigids were far more solid and reliable than the Stralis tractors on their fleets – and not because the tractors were particularly bad! There are however, as always, a few niggles worth being aware of. Here are some issues we’ve heard of with some of the high mileage, less cared for trucks.

1. Warning lights

Erroneous dashboard warning lights, usually related to the engine or gearbox, were reported by most of our operators. The good news, however, is that these usually clear if the ignition is turned off for a minute or two, leaving no trace of a fault on the diagnostics.

2. Electrical problems

More real electrical problems are reported to occur behind the dashboard and footwell, caused by water leaking into the door pillars and filling them up. Cause unknown.

3. Interior trim

Interior trim defects are still common on these trucks, especially where multiple drivers are using the vehicle, and consequently less care is taken.

4. Door reflectors

Following on from that, the small triangular reflectors set into the driver’s door panel regularly shatter. This happens when drivers push the seat all the way back without checking the seatbelt is fully retracted first. The belt runs through the back of the seat, and becomes trapped between that and the bunk. This leaves the metal end flapping around, which then smashes the reflector.

5. Propshaft joints

Some operators have had issues with propshaft centre joint failures.

6. Hydraulic steering

Some problems with the hydraulic pressure dropping on rear-steer models like ours, leaving the wheels to turn in the opposite direction to that intended.

7. Sunroof

Leaky sunroof seals – but from where the frame meets the cab NOT where the glass meets the frame. Worth being aware of as it took one of our operators many attempts to solve this.

8. Door hinge

Reports that doors are vulnerable to being bent when thrown open or caught by the wind. This leads to air whistling and water leaking in along the top, where the door no longer lines up with the frame.

9. Check-strap

Also, the check-strap bolted to the bottom hinge on the doors is known to become weak to the point where it snaps.

10. AdBlue

Regular AdBlue faults reported, of various flavours.

Click here to view all of the used Iveco Stralis trucks we have in stock.

About the Author

img

George Barrow

George has been writing about nearly anything with wheels for the past 15 years and is the UK jury member of the International Van of the Year and International Pick-Up Award.

Share this article

axle
bodytype
cabtype
Emissions
Vehicle Type
make
model
;